Automotive advancements

Re: Automotive advancements

Postby professor science » Wed Mar 26, 2014 1:44 pm

More KERS stuff from Volvo… really, this is a whole new thing. It's so exciting to be alive!

Image

A mechanical kinetic energy recovery system (or KERS) is smaller and lighter than a petrol-electric hybrid system, and in real-world conditions it hacks back fuel consumption by a similar percentage to a hybrid. And without troubling the engineers too much, you can add an F1-style boost function, which gives you a big lump of torque on tap if you need to overtake. Or do big, smoky burnouts. All of this, plainly, is a Good Thing.

The sort of Good Thing that’s attracted big, globo-corp manufacturers like Volvo, which has just built a KERS-equipped S60 T5 development mule, which we’ve been driving around. At the fore, there’s the company’s older 254hp five-cylinder petrol engine, powering the front wheels, and astern there’s a Flybrid KERS system powering the back axle.

So, how does it work? Kinetic energy that you’d ordinarily lose to heat while braking is sent to a flywheel, which can capture 150 watt hours in around eight seconds of gentle braking. That’s the same amount of energy you’d need to charge 25 new iPhones captured in a third of the time it’d take a Toyota Prius.

Once it’s been recovered, it can be stored for about half an hour or used immediately, either as a supplement to the engine, or in one great big lump. Chose the former and it’ll cut consumption by up to 25 per cent. Chose the latter and you get 80hp added instantly. Obviously, we tried the latter.

This transforms it into a very un-Volvo-ey Volvo. Hit the KERS button and it puts on speed with a head butt, like a turbo-era hot hatch that’s found some boost. When we tried it on a very moist Silverstone, the rear tyres writhed and scratched a bit before both axles settled into a cohesive thrust, then it lunged forward in a great gust of torque, which lasts, we’re told, for up to ten seconds (we were on the baby Stowe circuit so couldn’t let it run its course). Less empirically, with KERS switched on, our 0-60mph time dropped from 7.68 seconds to 6.07 seconds.

And all this thrust comes from a little box of gears and clutches that weighs 60kg, requires virtually no maintenance, and will last for what the company claim is the realistic life of the car. The batteries in Volvo’s current petrol/electric hybrid weigh 300kg alone, and will have to be replaced after about a decade.

Flybrid reckon they can have a system ready for 2017, and while it’s not in the company’s official product plan, Volvo’s new SPA platform (previewed with the gorgeous Concept Estate and Concept Coupe) will be built to accept the technology. Other big names are coming forward too – JLR’s a partner and a mechanical KERS system has found its way onto an XF, and Lotus is working on a performance-focused system for its road cars.

But if you can’t wait for the manufacturers to wade into the tech, there’s a very cheap, very easy to experience KERS for yourself. Arriva is trialling the system on its buses, which are currently operating in Milton Keynes. Who says Top Gear don’t do real-world consumer advice?


via TopGear
Upgrade your grey matter 'cause one day it may matter.

Don't be in such a hurry to condemn a person because they don't do what you do, or think as you think. There was a time when you didn't know what you know today...

Image
User avatar
professor science
Site Admin
 
Posts: 6353
Joined: Sat May 27, 2006 5:28 am
Location: Kitchener, Ontario

Re: Automotive advancements

Postby Mandeep D » Thu Mar 27, 2014 1:33 pm

I can see that it'd be much easier to implement than a full hybrid system. You'd miss one of the main benefits of a series hybrid; being able to plug in. It hits the gas engine right where it counts immediately however - acceleration right after braking.

We made a 8 wheeled parallel hybrid here at work in the fall (by towing a battery electric vehicle with a diesel) :lol:
Jetta Kartell - making the world more complicated one project at a time.
User avatar
Mandeep D
 
Posts: 2055
Joined: Thu Nov 02, 2006 11:10 am
Location: Cambridge, On

Re: Automotive advancements

Postby Maraschino Larry » Thu Mar 27, 2014 3:31 pm

LOL... "We've gone green!"
.**CLUB.**
**.*SODA**.*

tripwalking wrote:I'd be willing to split it straight up the crotch.
User avatar
Maraschino Larry
 
Posts: 8907
Joined: Sat May 27, 2006 12:57 pm
Location: HybridAyr

Re: Automotive advancements

Postby Dreamstate » Fri Mar 28, 2014 12:20 pm

NICE. Reminds me of the old gassifier trailers
Mercedes-Benz. The Cadillac of automobiles.
User avatar
Dreamstate
 
Posts: 7615
Joined: Tue Aug 08, 2006 9:56 pm
Location: Kitchener, Ontario

Re: Automotive advancements

Postby Mandeep D » Fri Mar 28, 2014 12:23 pm

Haha! I'm not really supposed to talk about it, but it's going up on the website soon anyways...

We've developed a battery electric drivetrain that basically bolts in our existing chassis. It will run for 3+ hours, charge in ~3 hours, and pull our 9000lb truck up 23000' of elevation over ~50kms at 14 km/hr with a 1500lb payload. :D

We have our own motor design, and some stuff I really can't talk about :shock:

This WILL be big for us :heart:
Jetta Kartell - making the world more complicated one project at a time.
User avatar
Mandeep D
 
Posts: 2055
Joined: Thu Nov 02, 2006 11:10 am
Location: Cambridge, On

Re: Automotive advancements

Postby Dreamstate » Sat Mar 29, 2014 9:53 am

Anything to get fossil fuel fumes out of those mines. I can only imagine the air quality down there.
Mercedes-Benz. The Cadillac of automobiles.
User avatar
Dreamstate
 
Posts: 7615
Joined: Tue Aug 08, 2006 9:56 pm
Location: Kitchener, Ontario

Re: Automotive advancements

Postby mushroom_curry » Tue Apr 01, 2014 2:53 pm

You start to enjoy the smell of a mine after some time... memories.
you won't curry any favours with me.
User avatar
mushroom_curry
 
Posts: 5088
Joined: Mon Jul 05, 2010 9:47 pm
Location: Portlandia

Previous

Return to Technical Discussions

Who is online

Users browsing this forum: No registered users and 1 guest

cron